Pengaruh Jenis Aktivator Adsorben Abu Boiler Pabrik Kelapa Sawit Terhadap Mutu Minyak Sawit Mentah

Authors

  • Ika Ucha Pradifta Rangkuti Sekolah Tinggi Ilmu Pertanian Agrobisnis Perkebunan
  • Heri Purwanto Sekolah Tinggi Ilmu Pertanian Agrobisnis Perkebunan
  • Hilda Sry Utami Pohan Sekolah Tinggi Ilmu Pertanian Agrobisnis Perkebunan

DOI:

https://doi.org/10.23960/jtep-l.v10i3.351-355

Abstract

Palm oil mill boiler ash is one of the substances that can be used as an adsorbent. The adsorbent can absorb certain components of a fluid phase, which before being applied needs to be activated using chemicals so that the effectiveness of the absorption is increasing. The use of adsorbents in CPO is quite effective in maintaining its quality. Several previous studies have studied the application of adsorbents in maintaining the quality of CPO. The purpose of the study was to utilize palm oil mill boiler ash as an adsorbent of several types of activators and to determine the effect of effective activator types in application to the quality of CPO oil. This study used a non-factorial completely randomized design with adsorbent activation treatment using H3PO4 and NaCl with a concentration of 10% and soaked for 24 hours. There are 3 parameters observed in the adsorbent application to CPO, namely free fatty acids, water content, and dirt content. The results showed that the adsorbent activated with H3PO4 was an effective adsorbent with a decrease in its free fatty acids up to 0.43%, water content decreased to 0.07%, but an increase in CPO impurities content of 0.24%. While the adsorbent activated using NaCl showed free fatty acids 0.22%, water content decreased by 0.03% and dirt content also increased by 0.24%.

 

Keywords:   adsorbent activator, crude palm oil, boiler ash, H3po4, Nacl

References

Ahmad, T., Rafatullah, M., Ghazali, A., Sulaiman, O., Hashim, R. 2011. Oil palm biomass-based adsorbents for the removal of water pollutants: A review. Journal of Environmental Science and Health - Part C Environmental Carcinogenesis and Ecotoxicology Reviews, 29(3): 177–222. DOI: 10.1080/10590501.2011.601847.

Dewi, R., Azhari, A., Nofriadi, I. 2020. Aktivasi karbon dari kulit pinang dengan menggunakan aktivator kimia KOH. Jurnal Teknologi Kimia Unimal, 9(2): 12–22.

Hasibuan, H. A. 2012. Kajian karakteristik minyak inti sawit indonesia dan produk. Jurnal Standarisasi, 14(2): 98–104.

Hasyim, U.H., Kurniaty, I., Mahmudah, H. Hermanti, M. 2019. Pengaruh waktu adsorpsi asam lemak bebas dalam minyak kelapa sawit mentah pada pembuatan bioadsorben limbah batang pisang. Jurnal Konversi, 8(1): 61–70.

Khuluk, R. H. 2016. Karbon Aktif Dari Tempurung Kelapa (Cocous nucifera L.) Sebagai Adsorben Zat Warna. [Skripsi]. Universitas Lampung.

Meidinariasty, A., Purnamasari, I., Zamhari, M., Fadarina, F., Permadi, J., Fadillah, N.Z., Luthfiah, S. 2020. Pengaruh variasi jenis abu boiler dan kosentrasi HCL terhadap sifat fisis silika gel hasil sintesis, Jurnal Kinetika, 11(03): 28–33.

Prianti, E., Malino, M. B. And Lapanporo, B. P. 2015. Pemanfaatan abu kerak boiler hasil pembakaran limbah kelapa sawit sebagai pengganti parsial pasir pada pembuatan beton. Positron, 5(1): 26–29. DOI: 10.26418/Positron.V5i1.9744.

Suprapto, S. 2009. Penanganan limbah pembakaran batubara pada pabrik tekstil: Studi kasus pabrik tekstil di Kabupaten Bandung. Jurnal Teknologi Mineral dan Batubara, 5(2): 19–31.

Triawan, D.A., Nesbah, N., Fitriani, D. 2017. Crude palm oil’s (CPO) fly ash as a low-cost adsorben for removal of methylen blue (mb) from aqueous solution. Jurnal Kimia Riset, 2(1): 10–15.

Yulianto, Y. 2020. Analisis quality control mutu minyak kelapa sawit di PT. Perkebunan Lembah Bhakti Aceh Singkil. Amina, 1(2): 72–78. DOI:10.22373/Amina.V1i2.36.

Yuniva, N. 2010 Analisa Mutu Crude Palm Oil (CPO) dengan Parameter Kadar Asam Lemak Bebas (ALB), Kadar Air dan Kadar Zat Pengotor Di Pabrik Kelapa Sawit Pekanbaru. Skripsi. Universitas Islam Negeri Sultan Syarif Kasim, Riau.

Downloads

Published

2021-09-29

Issue

Vol. 10 No. 3 (2021): September

Section

Articles

License

    1. Authors who publish with this journal agree to the following terms:

        1. Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution-ShareAlike 4.0 International Lice that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
        2. Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
        3. Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).

        4. Jurnal Teknik Pertanian Lampung

          Creative Commons License
          JTEPL is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.